Search results

I am chasing down the reason that my 4WD does not engage on my 2002. I'm pretty sure I got a bad remanufactured module from the parts store. While I was chasing down the wiring I happened to pull the dash switch. I have 2 questions: Does anyone know the voltage readings that should come out...

Recently I noticed that my transmission is slipping in reverse? No notable issue in Drive. 2002, well maintained, 175k. I tightened up the servo valve several years ago during a pan drop/filter change. Royal Purple fluid and regular filter/oil changes. Any ideas before I have a shop check it...

Just discovered that my very reliable '02 would not start when left in 4WD high? I drove to the airport in the snow and parked it and intentionally left it in 4WD thinking I might need it to back out. When I returned a day later and turned the key it would crank but not fire? Once I switched...

Hey Dan if you are still out there? Did you ever get a chance to post your 5.0 swap or at least the wiring diagram/modification that you went through?

I was just wondering if there was a way to swap a newer V6 eco-boost engine in an older Sport Trac? I own a 2004 right now and love everything but the low horsepower. The newer V-6's should be populating the salvage yards in the next couple of years, might be an opportunity? Easier than a 302...

I think the clutch pack in my rear differential is shot. I jacked up the rear and rotated one wheel and the other rotates freely. I've been hearing some noise from it in the last couple of days. Has anyone out there replaced the clutch pack? If so, how hard is it? I see Rock Auto has the...

Just found out that my passenger-side rear axle seems to have excessive in-out play? Is there a spec out there? Feels like about 1/4" - 3/8". Is this a c-clip replacement or is there a shim kit to tighten this up? Thanks!!

Hey I think it's time for me to swap out the 4wd engagement motor on my 2002 transfer case. Any tips, pictures, special instructions on this or is it an easy remove-reinstall?

I'm having trouble with my 4WD actuator sticking in the cold weather. I thought there was a post at one time that outlined the replacement process? Is it a simple swap or are there any adjustments to be made during install? I want to start by removing the motor and giving it a clean/lube...

Well, after 99,000 miles I decided to change the spark plugs in my '02 4wd. I realize now that if I ever do this again I'll have to warm up by: 1) Sitting on a chair in front of the grill for 20 minutes and screaming at the Ford emblem, might as well get it out of my system early. 2)...

The driver side power seat in my 2002 stopped working. I pulled the fuse (#30 according to the owners manual) and everything looks fine. Any suggestions??

I read an earlier message about someone planning to install an STS turbo system on their Trac. I'm seriously considering going this route since I have an '02 with TT & shackle lift, BFG 275's and I'm at 5000+ ft. elevation here on the Colorado front range. I'm not looking for a ton of power...

Has anyone used the E3 Diamond Fire spark plugs? Are they worth the investment?

Great! :angry: I just pulled the rear drivers-side drum off to check out the wear and everything is covered in diff lube!! Is there any special tools or instructions I will need to pull the seal & bearing for replacement? I saw the project for upgrading the rear breaks to disks, hoping that...

Hey everybody, I'm wondering what the major differences would be between the 2005 4.0 liter and mine (2004). I found this on the internet and would like to know how much modification/programming it would take to make it fit? Vortech Supercharger Kit for 2005 Ford Mustang with...

My "Check Engine" light just came on so I checked some former posts and got the Auto Zone lowdown. The code is PO401, which, according to their reference manual, has something to do with the EGR system. I popped the valve and other than some light carbon, nothing looked wrong. I went ahead...